Taiyuan ultraviolet sterilizer manufacturer benefits of environmental protection equipment Co., Ltd., Taiyuan, Shanxi Zhao Xiang 13231166569/0311-89943986/qq1838722340: UV sterilizer Taiyuan Taiyuan classification and structure and components of UV disinfection of drinking water disinfection by ultraviolet Taiyuan water status into open water Taiyuan gravity and confining pressure UV disinfection of drinking water UV disinfection Taiyuan. Currently used in enclosed UV disinfection of drinking water Taiyuan majority. UV disinfection of drinking water Taiyuan closed appliance disinfection lamp with a metal cylinder and the disinfection of the water enclosed. Enclosed Taiyuan UV disinfection of drinking water cylinder made of stainless steel, closed Taiyuan UV disinfection of drinking water wall do its polished to enhance the UV reflectance, enhanced UV radiation intensity of the cylinder body. Enclosed Taiyuan UV disinfection of drinking water in the barrel can be fitted with baffles to change the operating status of the water to avoid water dead. Enclosed Taiyuan ultraviolet disinfection of drinking water must have inlet, outlet and drain pipes, inlet flow rate can be set on the indicating instrument, in order to simplify closed drinking water UV disinfection Taiyuan structure, you can also drain pipe and a flow meter installed in the sterilizer connected pipeline. Enclosed UV disinfection of drinking water Taiyuan prominently instructions should have lit the lamp, lit timing instructions or UV intensity indicating instrument. Taiyuan UV disinfection of drinking water is a core component UV lamp, the role is to convert electrical energy into light energy ultraviolet. Taiyuan drinking water UV disinfection lamp is filled with inert gas and mercury vapor, low-pressure mercury UV lamp shell vapor pressure of 0.8Pa. Taiyuan single lamp UV disinfection of drinking water on site a lamp, the lamp is located in the center of the cylinder section. Taiyuan multi-lamp UV disinfection of drinking water in the tube layout principles, is to make drinking water UV disinfection Taiyuan various points within the cylinder sections have substantially the same intensity of ultraviolet radiation. Straight-tube low-pressure mercury quartz UV light disinfection implementation of national industry standards YY/T0 160-94. Taiyuan drinking water UV disinfection lamp quartz tube, transparent purple rate of not less than 92%, the working pressure 1.0MPa, test pressure 1.2MPa. In order to improve drinking water UV disinfection equipment Taiyuan total amount of water, you can use multiple UV disinfection of drinking water Taiyuan monocular body in series and parallel combinations. Practice has proved that the same radiation dose lighting, two kinds of combinations of sanitizing effect no significant difference. UV disinfection of drinking water Taiyuan series product specifications at rated flow rate should reach sterilizing radiation dose necessary. 2 UV disinfection of drinking water Taiyuan main technical characteristics of Taiyuan 2.1 UV disinfection of drinking water influent and effluent quality drinking water UV disinfection Taiyuan influent and effluent quality should meet the GB 3838-88 surface water quality requirements, applicable in centralized drinking water source protection areas of water bodies, total coliform value should be less than 10 000 / L. For surface water, drinking water Taiyuan during UV disinfection of drinking water disinfection as before, generally after coagulation, sedimentation, filtration and other treatment. GB5749-85 "drinking water health standards" requirement Taiyuan after UV disinfection of drinking water purification for drinking water sources that the total coliform value should not be greater than 1 000 / L. Taiyuan drinking water UV disinfection of treated surface water is purified, city buildings tank or a secondary water supply, can be used as sources of drinking water supplied directly to the water, the water quality should meet the drinking water health standards of the relevant provisions. Taiyuan drinking water UV disinfection bacteriological indicators that can take total coliforms less than 1 000 / L, total bacterial count of less than 2 000 / mL, chroma less than 15 degrees, the total iron content of less than 0.3mg / L, turbidity of less than 5 degrees. 2.2 UV disinfection of drinking water Taiyuan working conditions Taiyuan ambient temperature affect drinking water UV sterilizer UV light radiation intensity, thus affecting disinfection disinfection. Temperature 5 ℃ ~ 40 ℃ range of UV disinfection of drinking water disinfection Taiyuan effect changes with decreasing temperature, UV light output will be reduced below 5 ℃ even cause difficulty in starting the lamp. UV disinfection of drinking water in Taiyuan, the lamp set in a quartz tube, in addition to its role in preventing UV disinfection of drinking water Taiyuan lamp rupture pollute the water, there are also reduced because the water temperature is too low impact on the efficiency of the UV lamp function. Therefore, the drinking water UV disinfection Taiyuan water temperature and ambient temperature is above 5 ℃. UV disinfection of drinking water Taiyuan working environment relative humidity should be less than 65%, the maximum not more than 90%. High relative humidity, severe deterioration of the electrical components of the operating conditions, and the air, the small droplets increases, block UV intensity of the radiation decreases. Of the grid frequency is 50Hz. When the supply voltage changes, UV disinfection of drinking water Taiyuan radiation intensity UV lamp voltage rises with enhanced UV disinfection of drinking water Taiyuan capacity increased. Taiyuan UV disinfection of drinking water supply voltage should be stabilized at 220V ± 10% range, in which the supply voltage fluctuation range, the sterilizer disinfection capacity will be between 15% to 20% of the variation. 2.3 Taiyuan UV disinfection of drinking water disinfection capability disinfectant Taiyuan UV disinfection of drinking water disinfection capability refers to the case in the nominal amount of water to kill microorganisms in water features. Taiyuan UV disinfection of drinking water disinfection capacity of its physical expression represents the state of the irradiation dose: radiation dose = radiation intensity X sterilizer effective water volume (L) / sterilizer rated into the water × 3.6 OK Taiyuan UV disinfection of drinking water disinfection capability is the core issue of how to determine the radiation dose. Killing microbes require different type of irradiation dose, and the microorganism is present in a wide variety of water. Selected ultraviolet disinfection of drinking water Taiyuan irradiation dose is too high will waste unnecessary energy, too low and reach the purpose of disinfection. Disinfection of water pollution should focus on killing the disease through the intestinal bacteria, generally considered Taiyuan UV disinfection of drinking water can be provided not less than the minimum irradiation dose 9 000μW / (cm2 · s), manufactured products should be greater than 12 000μW / (cm2 · s). Taiyuan in UV disinfection of drinking water, the UV radiation intensity of each point is different. UV lamp emitted through the quartz tube cause some attenuation of the intensity passing through the water layer with the water depth increases. UV disinfection of drinking water in Taiyuan how only the case of lamps, ultraviolet radiation within the cylinder cross-section intensity distribution is more complex calculations to ensure that each point strength is broadly consistent with the structural design of the primary problem. UV disinfection of drinking water Taiyuan effective use of the process, increasing the radiation dose is reduced over time, mainly because of Taiyuan drinking water UV disinfection lamp radiation intensity changes, ultraviolet disinfection of drinking water tube Taiyuan the body surface and the quartz sleeve fouling caused by ultraviolet reflectivity and transparency purple is also an important reason for lower. UV disinfection of drinking water Taiyuan effective usage time of the lamp is its radiation intensity from the factory standard value dropped by 30% cumulative time, Taiyuan drinking water UV disinfection lamp life should be valid up to 13000h. UV disinfection of drinking water Taiyuan specified by the manufacturer in proximity useful life, should strengthen the monitoring of water quality, timely replacement of failed lamps. In actual operation, where necessary, the use of the standard value of the lamp failure, appropriate reduction of Taiyuan ultraviolet disinfection of drinking water into the water to ensure the necessary radiation dose, you can still obtain satisfactory water quality. 2.4 microorganisms by ultraviolet light irradiation resurrection Taiyuan UV disinfection of drinking water, a variety of different microorganisms are as ultraviolet radiation damage and even death. However, all of any biological ability to repair damage to a certain microbial no exception. Microbial UV damage can be reversed by visible light is called resurrection, effective 330nm ~ 480nm wavelength range includes the visible and near UV. Repair of microbial species and due to hit by ultraviolet extent varies. Some lack the enzyme microorganism matt light resurrection resurrection capability. UV fluence increases, photoreactivation rate decreased when the dose reaches 60 000μW/cm2, the E. coli photoreactivation disappear. Photoreactivation mechanisms are: the action of the enzyme photoreactivation, connected together can be reversed photoproduct formation of thymine dimers and monomers depolymerization, the DNA to restore normal function and structure of the DNA replication at the site of injury ignored and bypassed to achieve cutting repair and recombination repair. In order to avoid the phenomenon of photoreactivation, UV disinfection of drinking water Taiyuan should guarantee a certain dose of ultraviolet irradiation, sterilization should be installed in the tank outlet pipe, after disinfection of the water-box, to avoid prolonged contact with the light. 3 UV sterilizer Taiyuan Taiyuan Monitoring System 3.1 UV sterilizer lamp UV radiation intensity Taiyuan ultraviolet radiation intensity ultraviolet disinfection with ultraviolet radiation intensity was determined by measuring, the instrument shall be approved by the national legal units calibrated and the calibration validity period. When the lamp should be measured at the horizontal position, the instrument receiving the probe in the middle of the lamp surface normals at 1m. Ambient temperature of 25 ℃ ± 3%, relative humidity not exceeding 65%, the stability of the discharge tube before measurement time is not less than 10min, electrical measuring instrument accuracy is not less than 0.5, ballasts comply with GB2313 requirements, supply voltage 220V ± 2%, 50Hz. 3.2 Taiyuan UV sterilizer sterilizer sterilizer irradiance irradiance measured using the same instrumentation and measurement conditions 4.1. Instrument sterilizer test probe is placed holes, the distance from the surface is less than 5cm. The measured radiation intensity and the nominal flow of water residence time in the sterilizer is the radiation dose of the product. 3.3 Taiyuan UV sterilizer for water disinfection monitoring of natural water disinfection should meet the requirements. Sterilizer lamp fully open. In the case of nominal water disinfection, but also water quality should meet the total bacterial count is less than 100 / mL, total coliform count is less than 3 / L. Water testing shall conform to "drinking water standards test" (GB5750). 3.4 Taiyuan artificial ultraviolet disinfection disinfection detect contamination indicator bacteria using Escherichia coli 8099. Will be viable count of bacteria, with dechlorinated tap water dubbed 1 000cfu / L of water contamination do disinfection test, the number of total coliforms in water is less than 3 / L. 4 Taiyuan UV sterilizer sterilizer operation and management of the operation and management is not complicated. Usually should be noted whether all sterilizer lamp lit, the power supply voltage is normal, the inlet and outlet is unobstructed. Regular water quality monitoring, the tube should be increased monitoring frequency near the end validity, timeliness replace the lamp failure. Every three months on the quartz glass tube, the tube, the tube wall sterilizer cleaned once, first scrub with gauze dipped in alcohol, and then wipe with a soft cloth, clean and working gloves should be worn to prevent hand oil contamination, affecting ultraviolet transmittance and reflectivity. This information from the ultraviolet disinfection Taiyuan Taiyuan Environmental Protection Equipment Co., Ltd. Zeppelin self-publish, there are business please contact Environmental Protection Equipment Co., Ltd., Taiyuan Zeppelin. ?